Skip to Content

CIP Acid Rinse

This page contains information on CIP Acid Rinse for veterinary use.
The information provided typically includes the following:
  • CIP Acid Rinse Indications
  • Warnings and cautions for CIP Acid Rinse
  • Direction and dosage information for CIP Acid Rinse

CIP Acid Rinse

This treatment applies to the following species:
Manufacturer: Aspen Dairy Solutions

Acid CIP Cleaner

Formula ingredients contain no phosphorus.

FOR INDUSTRIAL USE ONLY

Directions For Use

Cleaning Pipelines

1. Pre-flush pipelines and milking units with large volume of potable water.

2. Prepare wash solution using proper use dilution of an appropriate chlorinated alkaline cleaner following label directions carefully.

3. Circulate wash solution through system for 8-10 minutes. Brush-wash all parts not coming in contact with the wash solution. Wear impervious gloves when brush-washing equipment.

4. Rinse with large volume of potable water to remove all wash solution. Allow to drain.

5. Finish with acidified water rinse. Add 0.78 mL of CIP Acid Rinse per Liter of potable water (1 US fl oz/10 US Gal). Rinse system and allow to drain.

6. Just before milking (no sooner than 30 minutes), sanitize by circulating proper ppm solution of a recommended sanitizer. Drain completely.

Cleaning Bulk Tanks

1. Pre-flush bulk tank with large volume of potable water.

2. Prepare wash solution in volume necessary to properly operate the spray device, using proper use dilution of an appropriate chlorinated alkaline cleaner following label directions carefully.

3. Spray-wash for 8-10 minutes. Disconnect return line and drain. Inspect all milk zone surfaces for cleanliness. Prepare wash solution using 30 gms of a chlorinated manual cleaner per Litre of hot water (4 US oz/US Gal). Brush-wash valve, outside of tank and any part of tank not cleaned by spraying system. Wear impervious gloves when brush-washing equipment.

4. Rinse inside and outside of bulk tank with potable water to remove all wash solution. Allow to drain.

5. See steps 5 and 6 above.

*Where local or state regulations are in effect, consult authorities for additional information.

NOTE: CIP Acid Rinse is not a sanitizer.

Avoid food contamination during application and storage. Do not store in food processing areas.

Rinse surfaces thoroughly with potable water after use.

KEEP OUT OF REACH OF CHILDREN

Danger

Causes severe skin burns and eye damage.

Wash skin thoroughly after handling. Wear protective gloves/ protective clothing/ eye protection/ face protection. Do not mix with bleach or other chlorinated products - will cause chlorine gas.

IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. IF ON SKIN (or hair): Remove/ Take off immediately all contaminated clothing. Rinse skin with water/ shower. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a POISON CENTER or doctor/ physician. Wash contaminated clothing before reuse.

READ SAFETY DATA SHEET (SDS) BEFORE USING THIS PRODUCT

EMERGENCY HEALTH INFORMATION: Contact local poison control.

Manufactured for: Aspen Veterinary Resources®, Ltd., 3155 Heartland Drive, Liberty, MO 64068

1-800-203-5620

NET CONTENTS:

 

 

18.9 L (5 US GAL)

6301372

760618/5300/1114

56.8 L (15 US GAL)

6301373

760619/5300/1114

208 L (55 US GAL)

6301374

760620/5300/1114

1150 L (304 US GAL)

6301375

760622/5300/1114

NAC No.: 1833001.0

ASPEN DAIRY SOLUTIONS
W7209 STATE ROAD 49, WAUPUN, WI, 53963-9677
Telephone:   920-345-1380
Website:   www.aspendairysolutions.com
Every effort has been made to ensure the accuracy of the CIP Acid Rinse information published above. However, it remains the responsibility of the readers to familiarize themselves with the product information contained on the US product label or package insert.

Copyright © 2016 North American Compendiums. Updated: 2016-08-21

Hide