Skip to Content

BioSentry Acid Tray Wash (Canada)

This page contains information on BioSentry Acid Tray Wash for veterinary use.
The information provided typically includes the following:
  • BioSentry Acid Tray Wash Indications
  • Warnings and cautions for BioSentry Acid Tray Wash
  • Direction and dosage information for BioSentry Acid Tray Wash

BioSentry Acid Tray Wash

This treatment applies to the following species:
Manufacturer: Vétoquinol

FOR INDUSTRIAL AND COMMERCIAL USE ONLY

For Use in Food Processing Plants

Ideal for Use Through Chemical Proportioners

BEFORE USING, READ THE MATERIAL SAFETY DATA SHEET (MSDS) FOR THIS PRODUCT

KEEP OUT OF REACH OF CHILDREN

DANGER

Active Ingredients

Phosphoric Acid

33.743%

Glycolic Acid

2.100%

OTHER INGREDIENTS:

64.157%

TOTAL:

100.000%

First Aid

Have label with you when obtaining treatment advice.

If In Eyes

Immediately flush with cool water. Remove contact lenses, if applicable, and continue flushing for 15 minutes. Obtain medical attention immediately.

If On Skin Or On Clothing

Take off contaminated clothing. Rinse skin immediately with plenty of water for 15-20 minutes. Get medical attention if irritation persists.

If Swallowed

Immediately give 1-2 glasses of water if able to swallow. Induce vomiting. Repeat procedure until vomited fluid is clear. Call a poison control centre or doctor for treatment advice. Do not give anything by mouth to an unconscious person.

If Inhaled

Move person to fresh air. If person is not breathing, call 911 or an ambulance, then give artificial respiration, preferably mouth-to-mouth, if possible. If breathing is difficult, give oxygen. Call a poison control centre or doctor for treatment advice.

Have the product container or label with you when calling a poison control center or doctor or going for treatment. For 24-hour medical emergency information on this product, call 1-800-498-5743 (U.S. & Canada) or 1-651-523-0318 (all other areas).

Precautionary Statements

DANGER: Contains surfactants, phosphoric and organic acids. This product is intended to be diluted before using. Concentrate causes eye and skin burns. May cause nose and throat irritation. Do not get in eyes, on skin or on clothing. Avoid breathing spray mist. Where there is potential for skin contact have available and wear as appropriate impervious gloves, apron, pants and jacket. Keep container tightly closed. Use and store only with adequate ventilation. Wash thoroughly after handling.

Chemical And Physical Hazards

This product is a formulated acidic detergent solution; contamination with other materials such as chlorine, chlorine-bearing compounds, organic chemicals, etc., may cause a dangerous chemical reaction. Keep all chemical and foreign materials away from this solution.

Corrosive material. Avoid contact with eyes and skin. Wear rubber gloves and chemical splash goggles. Keep out of reach of children.

BioSentry® Acid Tray Wash is an acidified, non-foaming cleaner for washing trays, plastic chick boxes, egg cases and filler flats in automatic tray washers. It is also an excellent acidic rinse and equipment descaler.

Directions For Use

FOR AUTOMATIC WASHERS: Use a 0.25%-0.75% solution (1/4-1 ounce per gallon of water) (2-8 ml/litre) in tepid to hot water (110°-160° F or 42°-70° C). Vary the amount depending on the soil load, water quality and water temperature. After cleaning with BioSentry® Acid Tray Wash, follow-up with an appropriate disinfecting solution. Consult your BioSentry® Technical Representative for recommendations. This is especially effective for use with chick processing tray washers.

FOR DESCALING TRAY WASHERS, EGG WASHERS AND SIMILAR EQUIPMENT: Use a 0.75%-4.0% solution (1-5 ounces per gallon of water) (8-40 ml/L), and operate the equipment without adding any items to be washed. Cold water is satisfactory for descaling.

AS AN ACIDIFIED RINSE: To prevent hard water and detergent spotting of items or lines previously cleaned with an alkaline detergent, add BioSentry® Acid Tray Wash to the final rinse water cycle.

PROGRAM FOR ALTERNATING CLEANERS: One week out of every 4-8 weeks, pending water hardness. Use in place of regular tray detergent to keep machines and nozzles free of scale and detergent residues. It also removes mineral scale and detergent residues from washed items.

FOOD PROCESSING PLANTS: Use BioSentry® Acid Tray Wash for cleaning hard surfaces and equipment. For food contact surfaces, rinse well with potable water before reuse. Avoid contamination of food during application and storage.

NOTE:

Safe for use on plastic, glass, stainless steel, mild steel, and galvanized metals.

Do not use on copper, brass, soft metals or concrete.

STORAGE AND DISPOSAL

Store in original container, in areas inaccessible to children. Keep container tightly closed. Do not store on side. Avoid creasing or impacting of side walls. Do not reuse empty container. Discard in trash or recycle.

NOTICE TO USER: This product is to be used only in accordance with the directions on the primary container labeling and attached leaflet.

Manufactured For: HACCO, Inc., 110 Hopkins Dr., Randolph, WI 53956 U.S.A.

Distributed in Canada By: Vétoquinol N.-A. Inc., 2000 ch. Georges, Lavaltrie, Quebec, Canada J5T 3S5

1-800-363-1700

BioSentry® is a Registered Trademark of Neogen Corporation.

Medical 1-800-498-5743

? 1-800-621-8829

NET CONTENTS:

Code:

Item #

5 Gallons (18.93 Litres)

NR.RR.

D12204609-CAN

NAC No.: 1234391.0

VETOQUINOL N.-A. INC.
Commercial Division

2000, CHEMIN GEORGES, LAVALTRIE, QC, J5T 3S5
Telephone:   450-586-2252
Order Desk:   800-363-1700
Fax:   450-586-4649
Website:   www.vetoquinol.ca
Email:   info@vetoquinol.ca
Every effort has been made to ensure the accuracy of the BioSentry Acid Tray Wash information published above. However, it remains the responsibility of the readers to familiarize themselves with the product information contained on the Canadian product label or package insert.

Copyright © 2016 North American Compendiums. Updated: 2016-08-21

Hide