Chloroprocaine

Generic Name: Chloroprocaine hydrochloride
Dosage Form: injection, solution

Chloroprocaine
Hydrochloride
Injection, USP

Rx only

Chloroprocaine Description

Chloroprocaine Hydrochloride Injection, USP is a sterile, nonpyrogenic, isotonic, isobaric solution. Each milliliter of 2% solution contains 20 mg of Chloroprocaine hydrochloride; 4 mg sodium chloride; with 1.8 mg sodium metabisulfite added in water for injection. Each milliliter of 3% solution contains 30 mg of Chloroprocaine hydrochloride; 2.1 mg sodium chloride; with 1.8 mg sodium metabisulfite added in water for injection. May contain hydrochloric acid and/or sodium hydroxide for pH adjustment. It contains no bacteriostat, antimicrobial agent or added buffer. Discard unused portion.

Slideshow: Vaccination Safety: Your Questions Answered

It is intended for production of local anesthesia by nerve block, infiltration, caudal or other epidural blocks.

Chloroprocaine Hydrochloride Injection has a pH of 3.1 (2.7 to 4.0).

Sodium Chloride, USP is chemically designated NaCl, a white crystalline compound freely soluble in water.

Chloroprocaine Hydrochloride Injection is identified chemically as 2-(diethylamino) ethyl 4‑amino-2 chlorobenzoate monohydrochloride. Its molecular Formula is: C13H19ClN2O2•HCl and the molecular weight is 307.22. It has the following structural formula:

Chloroprocaine - Clinical Pharmacology

Chloroprocaine, like other local anesthetics, blocks the generation and the conduction of nerve impulses, presumably by increasing the threshold for electrical excitation in the nerve, by slowing the propagation of the nerve impulse and by reducing the rate of rise of the action potential. In general, the progression of anesthesia is related to the diameter, myelination and conduction velocity of affected nerve fibers. Clinically, the order of loss of nerve function is as follows: (1) pain, (2) temperature, (3) touch, (4) proprioception, and (5) skeletal muscle tone.

Systemic absorption of local anesthetics produces effects on the cardiovascular and central nervous systems. At blood concentrations achieved with normal therapeutic doses, changes in cardiac conduction, excitability, refractoriness, contractility, and peripheral vascular resistance are minimal. However, toxic blood concentrations depress cardiac conduction and excitability, which may lead to atrioventricular block and ultimately to cardiac arrest. In addition, with toxic blood concentrations myocardial contractility may be depressed and peripheral vasodilation may occur, leading to decreased cardiac output and arterial blood pressure.

Following systemic absorption, toxic blood concentrations of local anesthetics can produce central nervous system stimulation, depression, or both. Apparent central stimulation may be manifested as restlessness, tremors and shivering, which may progress to convulsions. Depression and coma may occur, possibly progressing ultimately to respiratory arrest.

However, the local anesthetics have a primary depressant effect on the medulla and on higher centers. The depressed stage may occur without a prior stage of central nervous system stimulation.

Pharmacokinetics

The rate of systemic absorption of local anesthetic drugs is dependent upon the total dose and concentration of drug administered, the route of administration, the vascularity of the administration site, and the presence or absence of epinephrine in the anesthetic injection. Epinephrine usually reduces the rate of absorption and plasma concentration of local anesthetics and is sometimes added to local anesthetic injections in order to prolong the duration of action.

The onset of action with Chloroprocaine is rapid (usually within 6 to 12 minutes), and the duration of anesthesia, depending upon the amount used and the route of administration, may be up to 60 minutes.

Local anesthetics appear to cross the placenta by passive diffusion. However, the rate and degree of diffusion varies considerably among the different drugs as governed by: (1) the degree of plasma protein binding, (2) the degree of ionization, and (3) the degree of lipid solubility. Fetal/maternal ratios of local anesthetics appear to be inversely related to the degree of plasma protein binding, since only the free, unbound drug is available for placental transfer. Thus, drugs with the highest protein binding capacity may have the lowest fetal/maternal ratios. The extent of placental transfer is also determined by the degree of ionization and lipid solubility of the drug. Lipid soluble, nonionized drugs readily enter the fetal blood from the maternal circulation.

Depending upon the route of administration, local anesthetics are distributed to some extent to all body tissues with high concentrations found in highly perfused organs such as the liver, lungs, heart and brain.

Various pharmacokinetic parameters of the local anesthetics can be significantly altered by the presence of hepatic or renal disease, addition of epinephrine, factors affecting urinary pH, renal blood flow, the route of administration, and the age of the patient. The in vitro plasma half-life of Chloroprocaine in adults is 21 ± 2 seconds for males and 25 ± 1 seconds for females. The in vitro plasma half-life in neonates is 43 ± 2 seconds.

Chloroprocaine is rapidly metabolized in plasma by hydrolysis of the ester linkage by pseudocholinesterase. The hydrolysis of Chloroprocaine results in the production of ß-diethyl-aminoethanol and 2-chloro-4-aminobenzoic acid, which inhibits the action of the sulfonamides (see PRECAUTIONS).

The kidney is the main excretory organ for most local anesthetics and their metabolites. Urinary excretion is affected by urinary perfusion and factors affecting urinary pH.

Indications and Usage for Chloroprocaine

Chloroprocaine Hydrochloride Injection in single-dose containers without preservative and without EDTA, is indicated for the production of local anesthesia by infiltration, peripheral and central nerve block, including lumbar and caudal epidural blocks.

Chloroprocaine Hydrochloride Injection is not to be used for subarachnoid administration.

Contraindications

Chloroprocaine Hydrochloride Injection is contraindicated in patients hypersensitive (allergic) to drugs of the PABA ester group.

Lumbar and caudal epidural anesthesia should be used with extreme caution in persons with the following conditions: existing neurological disease, spinal deformities, septicemia and severe hypertension.

Warnings

LOCAL ANESTHETICS SHOULD ONLY BE EMPLOYED BY CLINICIANS WHO ARE WELL VERSED IN DIAGNOSIS AND MANAGEMENT OF DOSE-RELATED TOXICITY AND OTHER ACUTE EMERGENCIES WHICH MIGHT ARISE FROM THE BLOCK TO BE EMPLOYED, AND THEN ONLY AFTER ENSURING THE IMMEDIATE AVAILABILITY OF OXYGEN, OTHER RESUSCITATIVE DRUGS, CARDIOPULMONARY RESUSCITATIVE EQUIPMENT, AND THE PERSONNEL RESOURCES NEEDED FOR PROPER MANAGEMENT OF TOXIC REACTIONS AND RELATED EMERGENCIES (See also ADVERSE REACTIONS and PRECAUTIONS.) DELAY IN PROPER MANAGEMENT OF DOSE-RELATED TOXICITY, UNDERVENTILATION FROM ANY CAUSE AND/OR ALTERED SENSITIVITY MAY LEAD TO THE DEVELOPMENT OF ACIDOSIS, CARDIAC ARREST AND, POSSIBLY, DEATH.

Chloroprocaine Hydrochloride Injection, contains no preservative; discard unused injection remaining in vial after initial use.

Intra-articular infusions of local anesthetics following arthroscopic and other surgical procedures is an unapproved use, and there have been post-marketing reports of chondrolysis in patients receiving such infusions. The majority of reported cases of chondrolysis have involved the shoulder joint; cases of gleno-humeral chondrolysis have been described in pediatric and adult patients following intra-articular infusions of local anesthetics with and without epinephrine for periods of 48 to 72 hours. There is insufficient information to determine whether shorter infusion periods are not associated with these findings. The time of onset of symptoms, such as joint pain, stiffness and loss of motion can be variable, but may begin as early as the 2nd month after surgery. Currently, there is no effective treatment for chondrolysis; patients who experienced chondrolysis have required additional diagnostic and therapeutic procedures and some  required arthroplasty or shoulder replacement.

Vasopressors should not be used in the presence of ergot-type oxytocic drugs, since a severe persistent hypertension may occur.

To avoid intravascular injection, aspiration should be performed before the anesthetic solution is injected. The needle must be repositioned until no blood return can be elicited. However, the absence of blood in the syringe does not guarantee that intravascular injection has been avoided.

Mixtures of local anesthetics are sometimes employed to compensate for the slower onset of one drug and the shorter duration of action of the second drug. Experiments in primates suggest that toxicity is probably additive when mixtures of local anesthetics are employed, but some experiments in rodents suggest synergism. Caution regarding toxic equivalence should be exercised when mixtures of local anesthetics are employed.

Chloroprocaine Hydrochloride Injection contains sodium metabisulfite, a sulfite that may cause allergic-type reactions including anaphylactic symptoms and life-threatening or less severe asthmatic episodes in certain susceptible people. The overall prevalence of sulfite sensitivity in the general population is unknown and probably low. Sulfite sensitivity is seen more frequently in asthmatic than in nonasthmatic people.

Precautions

General:

The safety and effective use of Chloroprocaine depend on proper dosage, correct technique, adequate precautions and readiness for emergencies. Resuscitative equipment, oxygen and other resuscitative drugs should be available for immediate use. (See WARNINGS and ADVERSE REACTIONS). The lowest dosage that results in effective anesthesia should be used to avoid high plasma levels and serious adverse effects. Injections should be made slowly, with frequent aspirations before and during the injection to avoid intravascular injection. Syringe aspirations should also be performed before and during each supplemental injection in continuous (intermittent) catheter techniques. During the administration of epidural anesthesia, it is recommended that a test dose be administered (3 mL of 3% or 5 mL of 2% Chloroprocaine Hydrochloride Injection) initially and that the patient be monitored for central nervous system toxicity and cardiovascular toxicity, as well as for signs of unintended intrathecal administration, before proceeding. When clinical conditions permit, consideration should be given to employing a Chloroprocaine solution that contains epinephrine for the test dose because circulatory changes characteristic of epinephrine may also serve as a warning sign of unintended intravascular injection. An intravascular injection is still possible even if aspirations for blood are negative. With the use of continuous catheter techniques, it is recommended that a fraction of each supplemental dose be administered as a test dose in order to verify proper location of the catheter.

Injection of repeated doses of local anesthetics may cause significant increases in plasma levels with each repeated dose due to slow accumulation of the drug or its metabolites. Tolerance to elevated blood levels varies with the physical condition of the patient. Debilitated, elderly patients, acutely ill patients, and children should be given reduced doses commensurate with their age and physical status. Local anesthetics should also be used with caution in patients with hypotension or heart block.

Careful and constant monitoring of cardiovascular and respiratory (adequacy of ventilation) vital signs and the patient’s state of consciousness should be accomplished after each local anesthetic injection. It should be kept in mind at such times that restlessness, anxiety, tinnitus, dizziness, blurred vision, tremors, depression or drowsiness may be early warning signs of central nervous system toxicity.

Local anesthetic injections containing a vasoconstrictor should be used cautiously and in carefully circumscribed quantities in areas of the body supplied by end arteries or having otherwise compromised blood supply. Patients with peripheral vascular disease and those with hypertensive vascular disease may exhibit exaggerated vasoconstrictor response. Ischemic injury or necrosis may result.

Since ester-type local anesthetics are hydrolyzed by plasma cholinesterase produced by the liver, Chloroprocaine should be used cautiously in patients with hepatic disease.

Local anesthetics should also be used with caution in patients with impaired cardiovascular function since they may be less able to compensate for functional changes associated with the prolongation of A-V conduction produced by these drugs.

Use in Ophthalmic Surgery:

When local anesthetic injections are employed for retrobulbar block, lack of corneal sensation should not be relied upon to determine whether or not the patient is ready for surgery. This is because complete lack of corneal sensation usually precedes clinically acceptable external ocular muscle akinesia.

Information for Patients:

When appropriate, patients should be informed in advance that they may experience temporary loss of sensation and motor activity, usually in the lower half of the body, following proper administration of epidural anesthesia.

Clinically Significant Drug Interactions:

The administration of local anesthetic solutions containing epinephrine or norepinephrine to patients receiving monoamine oxidase inhibitors, tricyclic antidepressants or phenothiazines may produce severe prolonged hypotension or hypertension. Concurrent use of these agents should generally be avoided. In situations when concurrent therapy is necessary, careful patient monitoring is essential.

Concurrent administration of vasopressor drugs (for the treatment of hypotension related to obstetric blocks) and ergot-type oxytocic drugs may cause severe, persistent hypertension or cerebrovascular accidents.

The para-aminobenzoic acid metabolite of Chloroprocaine inhibits the action of sulfonamides. Therefore, Chloroprocaine should not be used in any condition in which a sulfonamide drug is being employed.

Carcinogenesis, Mutagenesis, and Impairment of Fertility:

Long-term studies in animals to evaluate carcinogenic potential and reproduction studies to evaluate mutagenesis or impairment of fertility have not been conducted with Chloroprocaine.

Pregnancy Category C:

Animal reproduction studies have not been conducted with Chloroprocaine. It is also not known whether Chloroprocaine can cause fetal harm when administered to a pregnant woman or can affect reproduction capacity. Chloroprocaine should be given to a pregnant woman only if clearly needed. This does not preclude the use of Chloroprocaine at term for the production of obstetrical anesthesia.

Labor and Delivery:

Local anesthetics rapidly cross the placenta, and when used for epidural, paracervical, pudendal or caudal block anesthesia, can cause varying degrees of maternal, fetal and neonatal toxicity.

(See CLINICAL PHARMACOLOGYPharmacokinetics).

The incidence and degree of toxicity depend upon the procedure performed, the type and amount of drug used, and the technique of drug administration. Adverse reactions in the parturient, fetus and neonate involve alterations of the central nervous system, peripheral vascular tone and cardiac function.

Maternal hypotension has resulted from regional anesthesia. Local anesthetics produce vasodilation by blocking sympathetic nerves. Elevating the patient’s legs and positioning her on her left side will help prevent decreases in blood pressure. The fetal heart rate also should be monitored continuously, and electronic fetal monitoring is highly advisable. Epidural, paracervical, or pudendal anesthesia may alter the forces of parturition through changes in uterine contractility or maternal expulsive efforts. In one study, paracervical block anesthesia was associated with a decrease in the mean duration of first stage labor and facilitation of cervical dilation. However, epidural anesthesia has also been reported to prolong the second stage of labor by removing the parturient’s reflex urge to bear down or by interfering with motor function. The use of obstetrical anesthesia may increase the need for forceps assistance.

The use of some local anesthetic drug products during labor and delivery may be followed by diminished muscle strength and tone for the first day or two of life. The long-term significance of these observations is unknown.

Careful adherence to recommended dosage is of the utmost importance in obstetrical paracervical block. Failure to achieve adequate analgesia with recommended doses should arouse suspicion of intravascular or fetal intracranial injection. Cases compatible with unintended fetal intracranial injection of local anesthetic injection have been reported following intended paracervical or pudendal block or both. Babies so affected present with unexplained neonatal depression at birth which correlates with high local anesthetic serum levels and usually manifest seizures within six hours. Prompt use of supportive measures combined with forced urinary excretion of the local anesthetic has been used successfully to manage this complication.

Case reports of maternal convulsions and cardiovascular collapse following use of some local anesthetics for paracervical block in early pregnancy (as anesthesia for elective abortion) suggest that systemic absorption under these circumstances may be rapid. The recommended maximum dose of each drug should not be exceeded. Injection should be made slowly and with frequent aspiration. Allow a 5-minute interval between sides.

There are no data concerning use of Chloroprocaine for obstetrical paracervical block when toxemia of pregnancy is present or when fetal distress or prematurity is anticipated in advance of the block; such use is, therefore, not recommended. The following information should be considered by clinicians who select Chloroprocaine for obstetrical paracervical block anesthesia: 1) Fetal bradycardia (generally a heart rate of less than 120 per minute for more than 2 minutes) has been noted by electronic monitoring in about 5 to 10 percent of the cases (various studies) where initial total doses of 120 mg to 400 mg of Chloroprocaine were employed. The incidence of bradycardia, within this dose range, might not be dose related. 2) Fetal acidosis has not been demonstrated by blood gas monitoring around the time of bradycardia or afterwards. These data are limited and generally restricted to nontoxemic cases where fetal distress or prematurity was not anticipated in advance of the block. 3) No intact Chloroprocaine and only trace quantities of a hydrolysis product, 2-chloro-4-aminobenzoic acid, have been demonstrated in umbilical cord arterial or venous plasma following properly administered paracervical block with Chloroprocaine. 4) The role of drug factors and non-drug factors associated with fetal bradycardia following paracervical block are unexplained at this time.

Nursing Mothers:

It is not known whether this drug is excreted in human milk. Because many drugs are excreted in human milk, caution should be exercised when Chloroprocaine is administered to a nursing woman.

Pediatric Use:

Guidelines for the administration of Chloroprocaine Hydrochloride Injection to children are presented in DOSAGE AND ADMINISTRATION.

Geriatric Use:

Clinical studies of Chloroprocaine Hydrochloride Injection did not include sufficient number of subjects 65 and over to determine whether they respond differently from younger subjects. Other reported clinical experience has not identified differences in responses between the elderly and younger patients. In general, dose selection for an elderly patient should be cautious usually starting at the low end of the dosing range, reflecting the greater frequency of decreased hepatic, renal, or cardiac function, and of concomitant disease or other drug therapy.

This drug and its metabolites are known to be substantially excreted by the kidney, and the risk of toxic reactions to this drug may be greater in patients with impaired renal function. Because elderly patients are more likely to have decreased renal function, care should be taken in dose selection, and it may be useful to monitor renal function.

Adverse Reactions

Systemic:

The most commonly encountered acute adverse experiences that demand immediate countermeasures are related to the central nervous system and the cardiovascular system. These adverse experiences are generally dose-related and may result from rapid absorption from the injection site, diminished tolerance or from unintentional intravascular injection of the local anesthetic solution. In addition to systemic dose-related toxicity, unintentional subarachnoid injection of drug during the intended performance of caudal or lumbar epidural block or nerve blocks near the vertebral column (especially in the head and neck region) may result in underventilation or apnea (“Total Spinal”). Factors influencing plasma protein binding, such as acidosis, systemic diseases that alter protein production, or competition of other drugs for protein binding sites, may diminish individual tolerance. Plasma cholinesterase deficiency may also account for diminished tolerance to ester-type local anesthetics.

Central Nervous System Reactions:

These are characterized by excitation and/or depression. Restlessness, anxiety, dizziness, tinnitus, blurred vision or tremors may occur, possibly proceeding to convulsions. However, excitement may be transient or absent, with depression being the first manifestation of an adverse reaction. This may quickly be followed by drowsiness merging into unconsciousness and respiratory arrest.

The incidence of convulsions associated with the use of local anesthetics varies with the procedure used and the total dose administered. In a survey of studies of epidural anesthesia, overt toxicity progressing to convulsions occurred in approximately 0.1 percent of local anesthetic administrations.

Cardiovascular System Reactions:

High doses, or unintended intravascular injection, may lead to high plasma levels and related depression of the myocardium, hypotension, bradycardia, ventricular arrhythmias and, possibly, cardiac arrest.

Allergic:

Allergic-type reactions are rare and may occur as a result of sensitivity to the local anesthetic. These reactions are characterized by signs such as urticaria, pruritis, erythema, angioneurotic edema (including laryngeal edema), tachycardia, sneezing, nausea, vomiting, dizziness, syncope, excessive sweating, elevated temperature, and possibly, anaphylactoid-type symptomatology (including severe hypotension). Cross sensitivity among members of the ester-type local anesthetic group has been reported. The usefulness of screening for sensitivity has not been definitely established.

Neurologic:

In the practice of caudal or lumbar epidural block, occasional unintentional penetration of the subarachnoid space by the catheter may occur (see PRECAUTIONS). Subsequent adverse observations may depend partially on the amount of drug administered intrathecally. These observations may include spinal block of varying magnitude (including total spinal block), hypotension secondary to spinal block, loss of bladder and bowel control, and loss of perineal sensation and sexual function. Arachnoiditis, persistent motor, sensory and/or autonomic (sphincter control) deficit of some lower spinal segments with slow recovery (several months) or incomplete recovery have been reported in rare instances. (See DOSAGE AND ADMINISTRATION discussion of Caudal and Lumbar Epidural Block). Backache and headache have also been noted following lumbar epidural or caudal block.

Overdosage

Acute emergencies from local anesthetics are generally related to high plasma levels encountered during therapeutic use of local anesthetics or to unintended subarachnoid injection of local anesthetic solution (see ADVERSE REACTIONS, WARNINGS, and PRECAUTIONS).

In mice, the intravenous LD50 of Chloroprocaine HCl is 97 mg/kg and the subcutaneous LD50 of Chloroprocaine HCl is 950 mg/kg.

Management of Local Anesthetic Emergencies:

The first consideration is prevention, best accomplished by careful and constant monitoring of cardiovascular and respiratory vital signs and the patient’s state of consciousness after each local anesthetic injection. At the first sign of change, oxygen should be administered.

The first step in the management of convulsions, as well as underventilation or apnea due to unintentional subarachnoid injection of drug solution, consists of immediate attention to the maintenance of a patent airway and assisted or controlled ventilation with oxygen and a delivery system capable of permitting immediate positive airway pressure by mask. Immediately after the institution of these ventilatory measures, the adequacy of the circulation should be evaluated, keeping in mind that drugs used to treat convulsions sometimes depress the circulation when administered intravenously. Should convulsions persist despite adequate respiratory support, and if the status of the circulation permits, small increments of an ultra-short acting barbiturate (such as thiopental or thiamylal) or a benzodiazepine (such as diazepam) may be administered intravenously; the clinician should be familiar, prior to the use of local anesthetics, with these anticonvulsant drugs. Supportive treatment of circulatory depression may require administration of intravenous fluids and, when appropriate, a vasopressor dictated by the clinical situation (such as ephedrine to enhance myocardial contractile force).

If not treated immediately, both convulsions and cardiovascular depression can result in hypoxia, acidosis, bradycardia, arrhythmias and cardiac arrest. Underventilation or apnea due to unintentional subarachnoid injection of local anesthetic solution may produce these same signs and also lead to cardiac arrest if ventilatory support is not instituted. If cardiac arrest should occur, standard cardiopulmonary resuscitative measures should be instituted. Recovery has been reported after prolonged resuscitative efforts.

Endotracheal intubation, employing drugs and techniques familiar to the clinician, may be indicated, after initial administration of oxygen by mask, if difficulty is encountered in the maintenance of a patent airway or if prolonged ventilatory support (assisted or controlled) is indicated.

Chloroprocaine Dosage and Administration

Chloroprocaine may be administered as a single injection or continuously through an indwelling catheter. As with all local anesthetics, the dose administered varies with the anesthetic procedure, the vascularity of the tissues, the depth of anesthesia and degree of muscle relaxation required, the duration of anesthesia desired, and the physical condition of the patient. The smallest dose and concentration required to produce the desired result should be used. Dosage should be reduced for children, elderly and debilitated patients and patients with cardiac and/or liver disease. The maximum single recommended doses of Chloroprocaine in adults are: without epinephrine, 11 mg/kg, not to exceed a maximum total dose of 800 mg; with epinephrine (1:200,000), 14 mg/kg, not to exceed a maximum total dose of 1000 mg. For specific techniques and procedures, refer to standard textbooks.

There have been adverse event reports of chondrolysis in patients receiving intra-articular infusions of local anesthetics following arthroscopic and other surgical procedures.  Chloroprocaine is not approved for this use (see WARNINGS and DOSAGE AND ADMINISTRATION).

Caudal and Lumbar Epidural Block:

In order to guard against adverse experiences sometimes noted following unintended penetration of the subarachnoid space, the following procedure modifications are recommended:

1. Use an adequate test dose (3 mL of 3% or 5 mL of 2% Chloroprocaine Hydrochloride Injection) prior to induction of complete block. This test dose should be repeated if the patient is moved in such a fashion as to have displaced the epidural catheter. Allow adequate time for onset of anesthesia following administration of each test dose. 2. Avoid the rapid injection of a large volume of local anesthetic injection through the catheter. Consider fractional doses, when feasible. 3. In the event of the known injection of a large volume of local anesthetic injection into the subarachnoid space, after suitable resuscitation and if the catheter is in place, consider attempting the recovery of drug by draining a moderate amount of cerebrospinal fluid (such as 10 mL) through the epidural catheter.

As a guide for some routine procedures, suggested doses are given below:

 1. Infiltration and Peripheral Nerve Block: Chloroprocaine Hydrochloride Injection


Anesthetic

Procedure

Solution

Concentration

%

Volume

(mL)

Total

Dose

(mg)

Mandibular

2

2 – 3

40 – 60

Infraorbital

2

0.5 – 1

10 – 20

Brachial plexus

2

30 – 40

600 – 800

Digital (without epinephrine)

1

3 – 4

30 – 40

Pudendal

2

10 each side

400

Paracervical

1

3 per each

of 4 sites

up to 120

(see also PRECAUTIONS)


    2.  Caudal and Lumbar Epidural Block: For caudal anesthesia, the initial dose is 15 to 25 mL of a 2% or 3% solution. Repeated doses may be given at 40 to 60 minute intervals.

For lumbar epidural anesthesia, 2 to 2.5 mL per segment of a 2% or 3% solution can be used. The usual total volume of Chloroprocaine Hydrochloride Injection is from 15 to 25 mL. Repeated doses 2 to 6 mL less than the original dose may be given at 40 to 50 minute intervals.

The above dosages are recommended as a guide for use in the average adult. Maximum dosages of all local anesthetics must be individualized after evaluating the size and physical condition of the patient and the rate of systemic absorption from a particular injection site.

Pediatric Dosage:

It is difficult to recommend a maximum dose of any drug for children, since this varies as a function of age and weight. For children over 3 years of age who have a normal lean body mass and normal body development, the maximum dose is determined by the child’s age and weight and should not exceed 11 mg/kg (5 mg/lb). For example, in a child of 5 years weighing 50 lbs (23 kg), the dose of Chloroprocaine HCl without epinephrine would be 250 mg. Concentrations of 0.5 – 1% are suggested for infiltration and 1 – 1.5% for nerve block. In order to guard against systemic toxicity, the lowest effective concentration and lowest effective dose should be used at all times. Some of the lower concentrations for use in infants and smaller children are not available in pre-packaged containers; it will be necessary to dilute available concentrations with the amount of 0.9% sodium chloride injection necessary to obtain the required final concentration of Chloroprocaine injection.

Preparation of Epinephrine Injections:

To prepare a 1:200,000 epinephrine-Chloroprocaine HCl injection, add 0.15 mL of 1 to 1000 Epinephrine Injection to 30 mL of Chloroprocaine Hydrochloride Injection.

Chloroprocaine is incompatible with caustic alkalis and their carbonates, soaps, silver salts, iodine and iodides.

Parenteral drug products should be inspected visually for particulate matter and discoloration prior to administration, whenever injection and container permit. As with other anesthetics having a free aromatic amino group, Chloroprocaine Hydrochloride Injection is slightly photosensitive and may become discolored after prolonged exposure to light. It is recommended that this product be stored in the original outer containers, protected from direct sunlight. Discolored injection should not be administered. If exposed to low temperatures, Chloroprocaine Hydrochloride Injection may deposit crystals of Chloroprocaine HCl which will redissolve with shaking when returned to room temperature. The product should not be used if it contains undissolved (e.g., particulate) material.

How is Chloroprocaine Supplied

Chloroprocaine Hydrochloride Injection, USP is supplied in single-dose containers as follows:


Concentration

 NDC No.

Container

Container Size

2%

0409-4169-01

Vial

30 mL

3%

0409-4170-01

Vial

30 mL

Store at 20 to 25°C (68 to 77°F). [See USP Controlled Room Temperature.]


Revised: March, 2010


Printed in USA                            EN-2433

Hospira, Inc., Lake Forest, IL 60045 USA

RL-1392

 

RL-1393

 

Chloroprocaine HYDROCHLORIDE 
Chloroprocaine hydrochloride injection, solution
Product Information
Product Type HUMAN PRESCRIPTION DRUG LABEL Item Code (Source) NDC:0409-4169
Route of Administration EPIDURAL, INFILTRATION DEA Schedule     
Active Ingredient/Active Moiety
Ingredient Name Basis of Strength Strength
Chloroprocaine HYDROCHLORIDE (Chloroprocaine) Chloroprocaine HYDROCHLORIDE 20 mg  in 1 mL
Inactive Ingredients
Ingredient Name Strength
SODIUM CHLORIDE 4 mg  in 1 mL
SODIUM METABISULFITE 1.8 mg  in 1 mL
WATER  
HYDROCHLORIC ACID  
SODIUM HYDROXIDE  
Packaging
# Item Code Package Description
1 NDC:0409-4169-01 25 VIAL, SINGLE-DOSE in 1 TRAY
1 30 mL in 1 VIAL, SINGLE-DOSE
Marketing Information
Marketing Category Application Number or Monograph Citation Marketing Start Date Marketing End Date
ANDA ANDA087447 04/16/1982
Chloroprocaine HYDROCHLORIDE 
Chloroprocaine hydrochloride injection, solution
Product Information
Product Type HUMAN PRESCRIPTION DRUG LABEL Item Code (Source) NDC:0409-4170
Route of Administration INFILTRATION, EPIDURAL DEA Schedule     
Active Ingredient/Active Moiety
Ingredient Name Basis of Strength Strength
Chloroprocaine HYDROCHLORIDE (Chloroprocaine) Chloroprocaine HYDROCHLORIDE 30 mg  in 1 mL
Inactive Ingredients
Ingredient Name Strength
SODIUM CHLORIDE 2.1 mg  in 1 mL
SODIUM METABISULFITE 1.8 mg  in 1 mL
WATER  
HYDROCHLORIC ACID  
SODIUM HYDROXIDE  
Packaging
# Item Code Package Description
1 NDC:0409-4170-01 25 VIAL, SINGLE-DOSE in 1 TRAY
1 30 mL in 1 VIAL, SINGLE-DOSE
Marketing Information
Marketing Category Application Number or Monograph Citation Marketing Start Date Marketing End Date
ANDA ANDA087446 04/16/1982
Labeler - Hospira, Inc. (141588017)
Revised: 07/2014
 
Hospira, Inc.
Hide
(web1)